Back to all

Aurora Drivers: Is It Time to Replace Your PCV Valve?

March 1, 2020

drive

The crankcase is the lower part of the engine where the crankshaft is housed and where the engine oil lives. The crankshaft is connected to the pistons that power the engine.


When you are diving around Aurora, fuel is burned in your vehicle engine, it pushes the pistons down and the crankshaft rotates and sends power to the transmission. Some of the explosive gases from combustion squeeze past the pistons and down into the crankcase.

Now this gas is about 70% unburned fuel. If it were allowed to remain in the crankcase, it would contaminate the oil and quickly turn it to sludge. Sludge is like Vaseline and clogs passages in the engine, leading to damage.

Also, the pressure build up would blow out seals and gaskets. So in the old days, there was just a hose that vented the crankcase out into the air. Obviously, not good for our air quality in Aurora, Illinois.

Enter the PCV valve. It's a small, one-way valve that lets out the gases from the crankcase and routes them back into the air intake system where they are re-burned in the engine. Fresh air comes into the crankcase through a breather tube. This makes for good circulation in the crankcase. And that gets the air out. As you can imagine, however, the valve gets gummed up over time.

Your vehicle manufacturer usually recommends they be changed somewhere between 20,000 to 50,000 miles/30,000 to 80,000 kilometers. Unfortunately, PCV valve replacement is left out of some vehicle owner's manuals, but your friendly service advisor at Tuffy Tire & Auto Service Aurora, we will make sure your PVC is replaced if needed.

Tuffy Tire & Auto Service Aurora
3190 N. Aurora Rd.
Aurora, Illinois 60502
630-898-6688

More articles from Tuffy Aurora

3 Winter Windshield Tips (Care of Windshield)

July 6, 2025

Cold weather can present some real challenges when it comes to your vehicle's windshield. Think of it. Your windshield is your window to the world when you're driving, and clear visibility is extraordinarily important for safe travels. So here are 3 tips to ensure that your windshield can do it... More

The Third Brake Light (Third Brake Light Service)

June 29, 2025

So you thought you only had two brake lights. Look again and you'll see one in the center at a higher level than the two on either side of the vehicle. They're sometimes in the inside of the vehicle behind the back window, or they could be in the deck lid, on the roof or on the spare wheel carr... More

Taking the Heat (Batteries in Hot Weather)

June 22, 2025

Quick question. Which is tougher on a vehicle's battery, the heat or the cold? Believe it or not, it's the heat. Think about it. The battery often sits in the engine compartment next to that motor generating lots of heat. That can accelerate corrosion in the battery and may even cause water i... More